Short answer: The DCH-006 (convex 430) is the most common 48V battery platform for folding e-bikes. It fits the Lectric XP family and 50+ other folding models — Samebike, KAISDA, BEZIOR, FIIDO, JINGHMA, Shengmilo, Engwe and more — all sharing the same 430mm convex shell, 5-pin discharge connector and 48V electrical architecture. If your folding bike's battery is a 430mm convex pack, the JD-006FZ is almost certainly the direct replacement.
1. What Is the DCH-006 Battery Platform?
The DCH-006 is a convex-head 430mm battery case used across the folding e-bike industry. "L430" (convex 430) describes the shell: a 430mm-long case with a raised/convex cap at the connector end. This is one of the highest-volume battery platforms in the folding e-bike market because dozens of brands built their frames around the same mold.
Key electrical specs (standard config)
| Parameter |
Value |
| Nominal voltage |
48V (13S) |
| Common capacities |
10.4Ah / 12.8Ah / 13Ah / 14Ah |
| Cell config |
13S4P (18650) |
| Discharge connector |
5-pin |
| Typical BMS |
30A hardware BMS |
| Shell length |
430mm (convex head) |
| Motor support |
500W / 750W (up to 1000W with 30A BMS) |
2. Full Compatibility List (54 Verified Models)
Verified against manufacturer specs and official product pages. 48V versions only (a 36V variant exists — see note below).
Lectric XP family
- Lectric XP 1.0 Step-Over (48V 10.4Ah)
- Lectric XP 2.0 Step-Over (48V 10.4Ah)
- Lectric XP 3.0 Long Range / XP eDition (48V 14Ah)
- Lectric XP Step-Over 1.0 / 2.0
- Lectric XP Lite 1.0 / 2.0 (48V 10.4Ah)
Note: Lectric XP Step-Thru models (1.0/2.0/3.0) use a different pointed-cap shell (FZZ/DCH-009 platform) — verify your connector and cap shape before ordering. The Step-Thru 3.0 has its own dedicated 48V 14Ah 672Wh pack.
Samebike / NAKXUS
- Samebike 20LVXD30-II
- Samebike Lo26
- Samebike XWXL09 (Silver Arrow)
- NAKXUS 20F063
KAISDA
BEZIOR
- BEZIOR X500 / X500 Pro / X1000 / X1500 (48V 12.8Ah)
- BEZIOR M20 / M2 / M26
FIIDO
- FIIDO M1 Pro (48V 12.8Ah)
- FIIDO M2
JINGHMA
Shengmilo
- Shengmilo FX-01 / R5s / MX-21
Engwe
- Engwe Engine Pro 750
- Engwe EP-2
Other verified models
- AVANTREK Cybertrack 200 (48V 10Ah)
- Vitilan V3 / V1 (48V 13.4Ah)
- DOHIKER
- CMACEWHEEL GT20 Pro
- Lankeleisi X2000 Plus
- LAFLY X3 / X5
- KETELES K8
- Cyrusher XF690
- CityFun Likebike (48V 10.4Ah)
- Eahora X7 (48V 10.4Ah)
- RICH BIT TOP-730
- VIVI FM20UL / SPA Series (36V/48V selectable)
- RQLLGOOD (48V 8Ah)
- Elbike Matrix Big Elite / Matrix VIP 13
36V variant: JD-006FZ also exists in 36V (VIVI 20", Hoverbot CB-8/CB-10, ADO A20F, ADO Beast 20F). The shell is identical — check your bike's voltage before ordering.
3. How to Confirm Your Bike Uses This Platform
Three checks, 30 seconds:
- Remove the battery from your folding bike.
- Measure the case length — it should be ~430mm (convex cap at one end).
- Check the connector — 5-pin discharge, and confirm the voltage label on the case (48V).
If all three match, the JD-006FZ is a drop-in replacement.
4. What to Check When Buying a Replacement
| Check |
Why it matters |
| Voltage (48V) |
A 36V pack will not run a 48V system |
| Capacity (Ah) |
10.4Ah ≈ 25–30 km range; 14Ah ≈ 35–45 km |
| Cell brand |
Samsung / LG / Panasonic cells last 800–1000 cycles |
| BMS rating |
30A covers 500–750W motors safely |
| Connector |
Must be 5-pin to match your harness |
| Certification |
Look for UL 2849 / UL 2271 compliance and UN38.3 |
5. Safety Notes
- Never charge below 0°C (lithium plating risk).
- Use the matching charger — a 48V charger for a 48V pack, never a 54.6V+ charger.
- CPSC recall awareness: some folding-bike batteries (e.g. VIVI silver-fish 36V packs, 2025 recall) have been recalled for fire risk. Check cpsc.gov before buying used batteries.
- Store at 50–60% charge for long-term storage.
6. Related Reading
The Bottom Line
The JD-006FZ is the industry-standard 48V platform for folding e-bikes — if your bike uses a 430mm convex 5-pin pack, this is your replacement. Match the voltage, confirm the connector, choose a trusted cell brand with a 30A BMS, and you'll get years of reliable service. ShunTongDa (stdbattery.com) offers JD-006FZ replacement packs with stated Samsung/LG cells and UL-certified chargers.
